江南体育下载地址 如何进行有效的保养？

来源：//www.scritchies.com日期：2021-11-16 发布人：admin
江南体育下载地址 可是我们从事混凝土搅拌行业者所立身的根本，可是有时却不知道要怎样完成良好的保养，下面就给大家详细讲解下：
Full automatic self loading mixer is the foundation of our people engaged in concrete mixing industry, but sometimes we don't know how to complete good maintenance. Here's a detailed explanation:
检查、发现问题排除故障
Check, find problems and eliminate faults
搅拌车更害怕在路上罐子不转，混凝土一般停罐不能超过2个小时，C40以上级别的混凝土在路上罐子就不能停。
The mixer truck is most afraid that the tank will not turn on the road. Generally, the concrete tank can not be stopped for more than 2 hours, and the tank of concrete above C40 can not be stopped on the road.
车子启动后，先让罐子低速旋转，围绕着车检查轮胎气压，看是否有漏气的胎，检查是否有石子、铁钉之类扎在胎里，及时清理干净。

全自动上料搅拌车

After the car starts, first let the jar rotate at a low speed, check the tire pressure around the car to see if there is a leaking tire, check if there are stones and nails stuck in the tire, and clean it in time.
检查侧灯务必保证照着轮胎边缘，因为工地会经常乱堆放钢筋之类杂物，而胎侧是更薄弱的。
When checking the side light, make sure it shines on the edge of the tire, because the construction site will often pile sundries such as reinforcement, and the sidewall is the weakest.
■保证水箱里有足够的水，有减水剂
■ ensure that there is enough water and water reducing agent in the water tank
因各种原因料太干，没有水添加放不出料的时候，减水剂就是救命稻草了，可以保证混凝土的流动性。
For various reasons, when the material is too dry to discharge without water, the water reducing agent is a life-saving straw, which can ensure the fluidity of the concrete.
■确认搅拌罐处于停止状态
■ confirm that the mixing tank is stopped
因为发动机启动时万一罐子处于高速旋转状态，瞬间的力会很大的，伤减速机和泵马达系统。
Because when the engine is started, if the tank is rotating at high speed, the instantaneous force will be great, damaging the reducer and pump motor system.
■检查特别注意事项
■ inspection precautions
减速机齿轮油，液压系统（马达、油泵、散热器）的油工作100小时更换，以后每1000小时更换（每年少更换1次）。
The gear oil of reducer and the oil of hydraulic system (motor, oil pump and radiator) shall be replaced after 100 hours of operation for the first time and every 1000 hours thereafter (at least once a year).
散热器、传动轴、滚道、拖轮、主槽转轴、操纵杆每月加注一次黄油。
Fill the radiator, transmission shaft, raceway, tug, main slot shaft and control lever with grease once a month.
江南体育下载地址 //www.scritchies.com/就给大家分享到这里，如有其他需求请查看我们官网，进行咨
Full automatic self feeding mixer //www.scritchies.com/ Let's share it here. If you have other needs, please check our official website for consultation
上一篇： 老司机告诉您搅拌车的一些重要事项！
下一篇： 自上料搅拌机造成触电的因素