Maintenance driving device of self feeding concrete mixing tank truck

驱动装置的作用是驱动混凝土贮罐转动，它由取力器、万向轴、液压泵、液压马达、操纵阀、液压油箱及冷却装置组成。如果这部分因故障停止工作，混凝土贮罐将不能转动，这会导致车内混凝土报废，严重的甚使整罐混凝土凝结在罐内，造成混凝土搅拌运输车报废。因此，驱动装置是否可靠是使用中一定要高度重视的问题。为保证驱动装置完好可靠，应做好以下维护工作：

The driving device is used to drive the concrete storage tank to rotate. It is composed of power take-off, universal shaft, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device. If this part stops working due to failure, the concrete storage tank will not rotate, which will lead to the scrapping of the concrete in the vehicle, and even cause the whole tank of concrete to condense in the tank, resulting in the scrapping of the concrete mixing truck. Therefore, whether the driving device is reliable or not is a problem that must be paid great attention to in use. In order to ensure the integrity and reliability of the driving device, the following maintenance work shall be done:

a．万向转动部分是故障多发部位，应按时加注润滑脂，并经常检查磨损情况，及时修理更换。车队应有备用的万向轴总成，以保证一旦发生故障能在几十分钟内恢复工作。

a. The universal rotating part is the part with frequent faults, so it should be filled with grease on time, and the wear should be checked frequently and repaired and replaced in time. The fleet shall have a spare cardan shaft assembly to ensure that it can resume operation within tens of minutes in case of failure.

b．保证液压油清洁。混凝土搅拌运输车工作环境恶劣，一定要防止污水泥沙进入液压系统。液压油要按使用手册要求定期更换。一旦检查时发现液压油中混入水或泥沙，就要立即停机清洗液压系统、更换液压油。

b. Ensure that the hydraulic oil is clean. The working environment of concrete mixer truck is bad, so it is necessary to prevent dirty cement sand from entering the hydraulic system. The hydraulic oil shall be replaced regularly according to the requirements of the operation manual. Once water or sediment is found in the hydraulic oil during inspection, stop the machine immediately to clean the hydraulic system and replace the hydraulic oil.

c．保证液压油冷却装置有用。要定时清理液压油散热器，避免散热器被水泥堵塞，检查散热器电动风扇运转是否正常，防止液压油温度超标。液压部分只要保证液压油清洁，一般故障不多；但生产厂家不同，使用寿命则不一样。

c. Ensure that the hydraulic oil cooling device is useful. Regularly check whether the hydraulic radiator is blocked by the hydraulic oil to prevent the hydraulic radiator from being blocked. As long as the hydraulic part keeps the hydraulic oil clean, there are few general faults; However, different manufacturers have different service life.

以上就是今天带给大家的知识， 江南app平台官网 车专注行业多年，为用户不断的提供有价值的内容，更多内容请继续关注我们： //www.scritchies.com/

The above is the knowledge brought to you today. Since the price of concrete mixing tank truck has been focused on the industry for many years, it has continuously provided users with valuable content. Please continue to pay attention to us for more content: //www.scritchies.com/